Repaired Wire Rope Is Acceptable For Use

Wound steel cable because of its strength has uses for lifting heavy objects pulling loads and holding immense weights stationary as in the case of the large steel cables used to hold suspension bridges.

Repaired wire rope is acceptable for use.

Make sure the load end of wire suspension ropes are equipped with proper size thimbles and secured by eyesplicing or. Destroy the wires by cutting the eye of the slings to prevent the slings or hitches from being attached to any other hardware. 1926 1413 a 4 iv where a wire rope is required to be removed from service under this section. Ask your crew to inspect samples and arrange for repair or replacement as required.

Cross bracing is acceptable in place of a midrail when the. Identify controls wire rope in continuous service should be. The use of repaired wire rope as suspension rope is prohibited. Once the wire ropes and slings are deemed defective put the do not use tag on them.

A wire rope is measured across its diameter at its widest point. The standard prohibits using repaired wire. Diameter reduction could be caused by one fault or a combination of faults. The use of repaired wire rope as suspension rope is prohibited.

Connection to reset the rope lay. Any new wire rope will stretch when the initial load is applied. The eyes will not reel onto the winch drum correctly but will keep to the cable together and bear 70 percent of the safe working load that the cable is capable of bearing. Make sure the use of repaired wire rope as suspension rope is prohibited.

Ensure wire suspension ropes are not joined together except through the use of eye splice thimbles connected with shackles or coverplates and bolts. Repair of wire rope that contacted an energized power line is also prohibited. Demonstrate review wire rope in use on site. F manila or other fiber or synthetic ropes shall not be used to support scaffolds upon which workers are using welding or burning equipment of any type sandblasting equipment or any chemical substance which may damage the rope by chemical action if splashed or spilled on the rope.

Make a temporary repair by using wire rope clips to turn two interlocking eyes into the parted and seized ends of the cable. After the initial. Damaged wire ropes and slings. D the use of repaired wire rope as suspension rope is prohibited 3 each scaffold and its components must be capable of supporting without failure its own weight and at least time the maximum intended load applied to it.

8 wire suspension ropes shall not be joined together except through the use of eye splice thimbles connected with shackles or coverplates and bolts. A 2 b 4 c 5 d 6 4 it is important to inspect scaffolds and scaffold components for visible defects before each work. Wire ropes should be replaced when the reduction in diameter is more than 5 from the nominal diameter. Explain dangers damage from wear and tear can reduce rope strength and capacity endangering workers who rely on the rope.