Removing Lock On Porsche Door

Porsche used a congealing grease that will later in life make the tumblers stick and even get worn out.

Removing lock on porsche door.

I m having the same issue. Again the passenger side door lock operates just fine and the drivers side door had just a. I suggest using some red loctite on this screw too in order to make sure it stays in place. Porsche 911 carrera door panel removal follow along with the photos in this project to work through the steps involved in replacing the.

Having done the removal and. I opened up the door removed the lock mechanism and inspected the door open microswitch. It would be a stretch to do the repair weld with the door attached. I m fairly sure the new part from porsche was only around 100.

928 537 903 02 with uneven codes. Pull off grommet from door frame and unscrew socket head screw. Part no 928 537 901 02 with even codes or part no. The 911 carrera door handles and door lock mechanism take a lot of use and abuse over the years and can experience many different failures.

Loosen metal screw arrow and pull out lock cylinder far enough that operating rod can be detached. I m going to remove the driver s door panel in order to get access to the door lock which needs to get replaced told so by authentic porsche dealer because the car always sees identifies the door as closed even though it s open. Fortunately replacing them isn t as bad as it might seem. I already have a new lock part number 955 531 015 07.

Bad door lock actuators on a 2011 porsche panamera 4 seem to be a common problem. The old lock cylinders with a chromeplated escutcheon are replaced by new lock cylinders. I then turned on the ignition and activated the locks using the central locking switch on the center console. I have read that door removal can be tough due to alignment and fit and should be left to the experts.

The fix is typically very easy remove the door panel remove the door handle and lock and then tighten the screw back down. Both door locks operated but the drivers side door was about 1 3 to 1 2 harder to turn in pressure than the passenger side door lock knob. Undo the door lock securing bolt using an allen key. Wayne at pelican parts will this work with a 1998 boxster driver side door lock too.

It was pointed out to me on a forum that the vw part that i recommended does not function correctly with key operation in the door to lower the win. Good luck dan the pod guy.